一．目的 Objective
规范拖把、抹布的清洁程序，防止交叉污染。
Standardize the cleaning procedure of mops and rags and avoid cross-contamination.
二．适用范围 Scope
生产区所用的拖把、抹布的清洁、消毒和日常管理。
Apply to the cleaning, disinfection and daily management of the mops and rags in the production area.
三．责任者 Responsibilities
操作人员、卫生员：按照本规程实施拖把、抹布的清洁、消毒或灭菌。
The operator, the sanitation man: responsible for the implementation of mops and rags cleaning and disinfecting in accordance with this procedure.
班长、IPC：按照本规程对拖把、抹布的清洁和消毒效果进行检查。
The monitor, IPC: responsible for checking the cleaning and disinfection effect in accordance with this procedure.
四．相关定义 Definition
无。No content.
五．工作程序 Procedure
1.一般原则
General principle
1.1.洁净区内拖把、抹布应使用无脱落物、易清洗、易消毒或灭菌的材料。
The material of the mops and rags should be no exfoliation，easily cleaned, easily disinfected or sterilized.
1.2.拖把、抹布用后应在规定的清洁间内及时清洗，每次消毒soup怎么读、灭菌后填写《 车间拖把、抹布消毒/灭菌记录10080》。
The mops and rags should be cleaned and disinfected in their respective cleaning rooms immediately after ud. And <the cleaning records of the mops and rags in workshop10080> should be timely filled.
1.3.不同洁净级别区域的拖把、抹布不得混用。针对不同用途的抹布需根据颜色进行区分使用，并在洁具架上标明用途，分类挂放。
Mops and rags in clean areas with different cleaning level should not be intermixed. The different u of rags should be distinguished between according to the different colors, and marked the us on the sanitary appliance shelf, hung them according to their categories.
1.4go dutch.kyp抹布使用要求
Operating requirements of the rags
1.4.1.用于擦拭与产品直接接触部位的抹布要专用，webcam并与擦拭其它部位的抹布要分开洗涤、消毒或灭菌、存放和使用。
The rags which directly contact with the product should be exclusively ud, hostingand parated from the rags ud in wiping other parts to clean, disinfection or sterilization, store and u.
1.4.2.抹布需定期进行更换，C、D级洁净区抹布三个月或出现明显破损时进行更换，A/B级洁净区抹布三个月或灭菌90次时进行更换，同时在《 车间拖把、抹布消毒/灭菌记录10080》备注中进行记录。
Change the rags every three months or which is broken in C, D clean area, and every three months or which is sterilized up to 90 times in A/B clean area. When change the rags should be noted in <the cleaning records of the mops and rags in workshop10080>.boast是什么意思
1.5.拖把使用要求
Operating requirements of the mops
tyrannosaur1.5.1.拖把应进行编号管理，编号方式为“使用区域-两位数的流水号”，使用区域有：一般区（简称YBQ）、（D或C或A/B）级洁净区（简称D或C或A/BJJQ）。具体形式如：YBQ-01、DJJQ-01、CJJQ-01、A/BJJQ-01。
Number the mops by “ud range-double digit rial number” and ud range contains general area(abbreviated to YBQ) and D, C, A/B clean area(abbreviated to D, C, A/BJJQ), such as YBQ-01,DJJQ-01,CJJQ-01,A/BJJQ-01.
1.5.2.拖把柄上用标签打印机打印并张贴该拖把的用途，形式为“用途：***”，具体用途可根据实际使用区域进行简短描述。
Print labels by “usage: ***” which is described simply according to ud range, and paste it to the mopstick.
1.5.3.拖把在清洁时，若该区域有双桶式榨水车，可先用榨水车对拖把进行初洗，然后再用“2.洗涤方法”中的方法进行彻底清洗。
Clean the mops by the mop wringer with double bucket first when there is a mop wringer
7395
with double bucket in the area, and then clean the mops by “2. cleaning methods” thoroughly.
1.5.4.清洁、消毒后的拖把应头朝下悬挂在指定洁具架上，洁具架下方应当有集水槽收集水滴，集水槽应定期进行清洁（一般区为7天，洁净区为3天）。
Hang the mops on the frames in their own storage room of cleaning tools and collect water by the tank. The tank should be cleaned regularly(7days in general area and 3 days in clean area).
1.5.5.拖把（指拖把头）需定期进行更换，C、D级洁净区拖把三个月或出现明显破损时进行更换、A/B级洁净区拖把三个月或灭菌90次时进行更换，同时在《 车间拖把、抹布消毒/灭菌记录10080》备注中进行记录。
yellowcardChange the mops every three months or which is broken in C, D clean area, and every three months or which is sterilized up to 90 times in A/B clean area. When change the rags should be noted in <the cleaning records of the mops and rags in workshop10080>.
1.6.清洁剂和消毒剂的使用要求参见《清洁剂和消毒剂使用规程1-00016》。
The u requirement of detergent and disinfectant e the “SOP for Using Detergent and Disinfectant 1-00016”.
2.洗涤方法Cleaning methods
pink是什么意思2.1.一般区 General area
2.1.1.拖把、抹布使用后先用饮用水加清洁剂洗涤，再用饮用水冲洗至冲洗水澄清、挤干。
The mops and rags should be washed first in drinking water with detergents, rin them in just drinking water to the flush water clear, and then squeeze the water.
2.1.2.拖把、抹布每周用消毒剂浸泡消毒一次，每次半小时，再用饮用水冲洗至冲洗水澄清、最后挤干。
The mops and rags should be disinfected once a week，and dip them in the disinfector for half an hour every time, rin them in just drinking water to the flush water clear，and
then squeeze the water.
2.1.3.洗涤后的拖把悬挂于指定洁具存放间的存放架上、抹布搭在挂钩上自然晾干。
Hang the mops and rags on the frames in their own storage room of cleaning tools, and dry them in the open air just after cleaning.
