手动葫芦维护操作手册
Manually Hoist Maintenance Manual
95什么意思维护方法
Maintenance methods
1.使用完毕应将葫芦清理干净并涂上防锈油脂，存放在干燥地方，防止手动葫芦受潮生锈和腐蚀。
Hoist clean up after u and should be coated with anti-rust oil,stored in a dry place,moisture to prevent rust and corrosion chain hoists.
手动葫芦
2.维护和检修应由较熟悉葫芦机构者进行，用煤油清洗葫芦机件，在齿轮和轴承部分，加黄油润滑，防止不懂本机性能原理者随意拆装。
Maintenance and repair should be more familiar with hoist bodies were carried out Mechanical cleaning hoist with kerone, Gears and bearings in part,Add Huangyou Run slip,Prevent tho who do not understand the principle of free disasmbly machine performance.
夜以继日的意思
办事处人员
3.葫芦经过清洗维修，应进行空载试验，确认工作正常，制动可靠时，才能交付使用。
After cleaning maintenance hoist,Load test should be carried out,Confirm working properly,Braking and reliable, theBe delivered.
4.制动器的摩擦表面必须保持干净。制动器部分应经常检查，防止制动失灵，发生重物自坠现象。
Brake friction surfaces must be kept clean.Brake parts should be inspected regularly,Prevent brake failure,Place heavy objects from falling phenomenon.
5.手动葫芦的起重链轮左右轴承的滚柱，可用黄油粘附在已压装于起重链轮轴颈的轴承内圈上，再装入墙板的轴承外圈内。
Around the sprocket Manually hoist lifting the ball bearing,Butter has been presd in adhesion can be installed on the lifting sprocket bearing inner ring on the journal,Load bearing wall and then outside the circle.
温庭筠望江南
6.手动葫芦在安装制动装置部分时，注意棘轮齿槽与棘爪爪部啮合良好，弹簧对棘爪的控制应灵活可靠，装上手链轮后，顺时针旋转手链轮，就将棘轮、摩擦片压紧在制动器座上，逆时针旋转手链轮，棘轮与摩擦片间应留有空隙。
Manual hoist brake part of the installation,Note with the pawl ratchet claw alveolar Department of meshing wells先生 Spring on the pawl control should be flexible, reliable,Sprocket to get started after installation,Clockwi bracelet round,Will ratchet, pre
sd the brake friction plate at,Counterclockwi rotation bracelet round,Ratchet and friction plate should be left between the gap.
7.为了维护和拆卸方便，手链条其中一节系开口链（不允许焊死）。
In order to maintain and facilitate the demolition, hand chain in which a ries open-chain (no welded).疯狂打泡泡
8.在加油和使用手动葫芦过程中，制动装置的摩擦面必须保持干净，并经常检查制动性有，防止制动失灵引起重物自坠。
In the refueling process and the u of manual hoist,Brake friction surfaces must be kept clean,And regular inspection of braking there,Prevent brake failure caud by heavy objects from falling.
使用规则
民生问题U Rules
1.严禁超载使用。
Overloading is strictly prohibited to u.
哄女朋友检讨书500字2.严禁用人力以外的其他动力操作。
Prohibited u of human power other than the operating
3.在使用前须确认机件完好无损，传动部分及起重链条润滑良好，空转情况正常。
Before U, be sure that parts intact,Transmission parts and lifting the chain oiled,Idling situation to normal.
4.起吊前检查上下吊钩是否挂牢。严禁重物吊在尖端等错误操作。起重链条应垂直悬挂，不得有错扭的链环，双行链的下吊钩架不得翻转。
Checked before lifting the upper and lower hook is hanging in prison. Weight suspended from the tip is strictly prohibited errors such operations. Lifting chain should be hung vertically, without twisting the wrong link, double chain hook frame shall turn next.
5.操作者应站在与手链轮同一平面内拽动手链条，使手链轮沿顺时针方向旋转，即可使重物上升；反向拽动手链条，重物即可缓缓下降。
The operator should stand on the same plane with the bracelet round hands pulled the chain, so that bracelet round clockwi, you can increa the weight; rever hands pulled the chain, you can slow down weight.
6.在起吊重物时，严禁人员在重物下做任何工作或行走，以免发生人身事故。
In lifting weights, strictly prohibited in any work under heavy objects or walking in order to avoid injury.
7.在起吊过程中，无论重物上升或下降，拽动手链条时，用力应均匀和缓，不要用力过猛，以免手链条跳动或卡环。
In the lifting process, regardless of weight up or down, hands pulled the chain, the force should be uniform gentle, not too much force, so as not to beat or hand chain ring.
8.操作者如发现手拉力大于正常拉力时，应立即停止使用。防止手链条磨损。
Operator found hand pulling tension greater than normal, they should immediately stop using. Hand chain to prevent wear and tear.
