Material Safety EKC Technology
Data Sheet
Phone 1-510-784-9105Fax: 1-510-784-9181
1.P R O D U C T A N D C O M P A N Y I D E N T I F I C A T I O N
Product Identifier:EKC830™
General U:
Posistrip ® Positive Photoresist Remover Product Description:Organic Solvent Blend
Revision and Date:Revision K, September 30, 2003MANUFACTURER EMERGENCY PHONE NUMBERS EKC Technology, Inc.(800) 424-93002520 Barrington Court CHEMTREC
Hayward, CA 94545-116324 hours/day, 7 days/week
(510) 784-9105
2.C O M P O S I T I O N / I N F O R M A T I O N O N I N G R E D I E N T S
WT. %
CAS REGISTRY #N-Methylpyrrolidone
鸟的英文
Proprietary 872-50-4
2-(2-Aminoethoxy)Ethanol
Proprietary
929-06-6
周岁邀请函
OSHA HAZARDOUS COMPONENTS (29 CFR 1910.1200)
EXPOSURE LIMITS 8 hrs. TWA (ppm)
OSHA PEL ACGIH TLV
DUPONT AEL
N-Methylpyrrolidone
None None 5 ppm 2-(2-Aminoethoxy)Ethanol
None
None
None
3.H A Z A R D S I D E N T I F I C A T I O N
E M E R G E N C Y O V E R V I E W
Light straw colored liquid with an amine odor.Caus skin and eye burns.
民航专业
Page 2 of 10 P O T E N T I A L H E A L T H E F F E C T S
INHALATION
May cau respiratory tract irritation. Prolonged or repeated exposure may cau
difficulty in breathing, headache, naua, vomiting, and drowsiness.
长辈送礼
EYE CONTACT
Caus burns.
SKIN CONTACT兔角
Caus burns.
INGESTION
Swallowing this material caus burns to mouth, throat, and stomach. Aspiration may
occur during swallowing or vomiting, resulting in lung damage.
REPRODUCTIVE TOXICITY
Prolonged or repeated exposure may cau reproductive disorders and birth defects
bad on tests with laboratory animals.粉的做法
TARGET ORGANS
Lungs, blood, lymph nodes, testes, thymus, kidneys, skin, and eyes
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
Overexposure may aggravate existing respiratory conditions.
CARCINOGENICITY
National Toxicology Program (NTP):Not listed
IARC Monographs:Not listed
OSHA:Not listed
ACGIH:Not listed
P O T E N T I A L E N V I R O N M E N T A L E F F E C T S
No adver effects have been noted.
4.F I R S T A I D M E A S U R E S
I N H A L A T I O N
Remove to fresh air immediately. If not breathing give artificial respiration. If breathing is difficult, give oxygen. Consult a physician.
E Y E C O N T A C T
Immediately flush eyes with water for at least 15 minutes. Have eyes examined and treated by a physician.
Page 3 of 10
S K I N C O N T A C T
Immediately flush skin with water for at least 15 minutes while removing contaminated clothing
and shoes. If redness or irritation occurs, ek medical attention.
I N G E S T I O N
Seek immediate medical attention. Maintain an open airway. Administer artificial respiration if necessary.
Never give anything by mouth to an unconscious person.
5.F I R E F I G H T I N G M E A S U R E S
Flashpoint and Method212°F (100°C)
Seta Flash Clod Cup (SFCC)
Flammable Limits in Air % by volume Lower: 2.0 Upper: 12.0
Autoignition Temperature Not available
Extinguishing Media Water, foam, carbon dioxide, dry chemical
U N U S U A L F I R E A N D E X P L O S I O N H A Z A R D S
None have been identified.
F I R E F I
G
H T
I N G I N S T R U C T I O N S
U water spray to cool containers and fire expod surfaces. Shut off fuel to fire if possible to do so without hazard.
赞美的力量F I R E F I
G
H T
I N G E Q U I P M E N T
Wear full protective clothing with lf-contained positive pressure breathing apparatus. If there is potential for skin exposure to EKC830™ e Section 8 of this MSDS.
H A Z A R D O U S C O M B U S T I O N P R O D U C T S
Carbon monoxide, nitrogen oxides
6.A C C I D E N T A L R E L E A S E M E A S U R E S
S P I L L O R L E A K P R O C E D U R E S
Evacuate area and keep personnel upwind. Cut off any source of ignition and ventilate the spill
area. Contain spill with absorbent material. Transfer absorbent and other contaminated materials to a UN approved covered container for disposal. Consult with Federal, State, and local
regulatory agencies to determine acceptable clean-up levels. Comply with Federal, State, and
local regulations on reporting releas.
Page 4 of 10 7.H A N D L I N G A N D S T O R A G E
S T O R A G E T E M P E R A T U R E
Storage in a dry, well-ventilated area 40° to 90°F (5° to 32°C) is recommended.
G E N E R A L
Keep in original tightly clod containers.
Keep away from strong oxidizing agents, anhydrides, isocyanates and organometallics.
Prevent skin and eye contact.
8.E X P O S U R E C O N T R O L S/P E R S O N A L P R O T E C T I O N
P E R S O N A L P R O T E C T I O N
RESPIRATORY PROTECTION
No respiratory protection is required when this material is handled under proper
ventilation, such as a wet bench or fume hood. If proper ventilation is not available, u a
NIOSH approved full-face respirator with canisters or cartridges specifically approved for
organic vapors. Whenever cartridges or canister respirators are ud, ensure the
frequent changing of the filter element. U a supplied air respirator when in doubt of the
atmospheric concentration. Consult 29 CFR 1910.134 regarding u of respirators.
PROTECTIVE CLOTHING
Take all precautions to prevent skin contact. Wear neoprene clothing, gloves, and
chemical resistant boots when there is a probability of liquid contact.
EYE/FACE PROTECTION
Wear chemical goggles or face shield when there is a probability of liquid contact.
9.P H Y S I C A L A N D C H E M I C A L P R O P E R T I E S
Freezing Point:Not available
Vapor Pressure:15 mm Hg at 77°F
(25°C)
Vapor Density: >1 (Air = 1)Appearance:Light straw
color
Specific Gravity: 1.00-1.10 Boiling Range:396-430°F
(202-221°C)
Evaporation Rate: <1 (Butyl Acetate = 1)Odor:Amine
Solubility in Water:Complete Physical State:Liquid
pH:Not applicable
Page 5 of 10
儿童绘画入门
10.S T A B I L I T Y A N D R E A C T I V I T Y
G E N E R A L
This product is stable at normal temperatures and conditions of storage.
I N C O M P A T I B L E M A T E R I A L S A N D C O N D I T I O N S T O A V O I D
Strong oxidizing agents, acids
H A Z A R D O U S D E C O M P O S I T I O N
Carbon monoxide, nitrogen oxides
H A Z A R D O U S P O L Y M E R I Z A T I O N
Will not normally occur.
11.T O X I C O L O G I C A L I N F O R M A T I O N
D A T A F O R
E K C830™
INHALATION
LC50, rat (4 hr): >2.65 mg/l, 4 hours. Signs of respiratory irritation were found.
EYE CONTACT
Corrosive
SKIN CONTACT
LD50, rabbit: >2000 mg/kg, not harmful. Corrosive. Not a nsitizer in guinea pigs.
INGESTION
LD50, rat: 3280 mg/kg, not harmful.
GENOTOXICITY
Not mutagenic in bacterial cells in culture.
TARGET ORGANS
Lungs, blood, lymph nodes, testes, thymus, eyes, and skin
