一．目的Objective
网络销售怎么做
规范生产区及其它控制区域地漏的清洁卫生规则。
To standardize the floor drain cleanliness regulation of production area and other control area.
二．适用范围Scope
适用于各生产车间、辅助车间及其它部门需进行卫生控制区域的地漏清洁、消毒和日常管理。
Applicable to the floor drain cleaning, disinfection and daily management of each production workshop, ancillary workshops and other departments in need of health control area.
三．责任者Responsibilities
操作工、卫生员：负责本标准操作规程的实施。
Operator、sanitation worker: responsible for the implementation of this SOP.
班长、IPC：负责监督检查本标准操作规程的实施
The team leader, IPC: responsible for supervising and checking the implementation of this SOP.
四．相关定义Definition
无 No content
五．工作程序Procedure
1.原则
Principle
—不得将混有固体杂物的污水直接倒入地漏，以免堵塞。
It is forbidden to dump liquid with solid sundries to the floor drain to avoid jamming.
—及时清除地漏周围的所有脏物，以免地漏堵塞。
Clean the sundries surrounded to avoid jamming.
—发现地漏堵塞应马上通知维修部门及时疏通。
Immediately inform the repairing department if there is a jam.
—生产操作时，不允许打开内盖操作。
It is forbidden to open the inside cover during production.
—地漏应按照工作程序要求进行清洁、消毒。
Follow the procedures when cleaning and disinfecting.
2.清洁、消毒程序
Procedures for cleaning and disinfecting
2.1.用外表面抹布将地漏周围污水、杂物清除。
Remove wage and debris around the floor drain with the outer surface cloth.
2.2.掀开地漏外盖、过滤网和地漏内盖，将液封中的脏水用外表面抹布吸干，并将液封内异物清除。
Open the outside cover, the filter and the inside cover, then blot the dirty water in the water stopper and clean the sundries inside.
2.3.用长柄、不易脱落毛丝的毛刷对地漏至存水弯处的下水管进行刷洗，并用洁净的工艺用水反复冲洗，直至无臭味及可见异物。
U the long-handled and not easy falling off hair wire brush to scrub the downcomer, and repeatedly washed with clean process water until no odor and visible foreign matter.
2.4.用工艺用水润湿的洁净外表面抹布擦拭地漏内壁，直至地漏内壁洁净无可见异物。
U the outer surface cloth which is wetted with process water to wipe the floor drain inside cover, until the floor drain inside cover is clean and free of visible foreign matter.
2.5.用工艺用水润湿的洁净外表面抹布擦拭地漏外盖、过滤网、地漏内盖，再用75%乙醇或公司规定的其他消毒剂擦拭消毒。
画鸡蛋U the outer surface cloth which is wetted with process water to wipe the floor drain outer cover, filter screen, and inside cover, then u the 75% ethanol or other prescribed disinfectant to wipe and disinfect.
2.6.取适量75%乙醇或公司规定的其他消毒剂，灌入下水管进行消毒。
Take the appropriate amount of 75% ethanol or other prescribed disinfectant to pour into the pipes to disinfect.
2.7.盖好地漏内盖，小儿弱智一般生产区于液封处倒入适量饮用水或纯化水，洁净区于液封处倒入适量75%乙醇或公司规定的其他消毒剂乐器学习网，加入量以液面过地漏内盖下沿形成有效液封为准，装好清洁的过滤网，盖上地漏外盖。
Cover the inside cover, then general production area u appropriate amount of drinking water or purified water to liquid al, clean area u appropriate amount of 75% ethanol o
r other prescribed disinfectant, and the dosage is subject to t form an effective liquid al, then cover the filter screen and outside cover.
2.8.用洁净的外表面抹布清除地漏四周残余水迹。
Clean the surroundings of the floor drain.
2.9.清洁结束后及时做好《地漏清洁记录1046》。
Fill in “The Cleaning Record of the Floor Drain 1046” in time.
2.10.应使用单独的抹布清洁地漏，使用后的抹布按照《拖把和抹布的清洁规程1-00020》中相关要求清洁、消毒，毛刷每次使用后用工艺用水冲洗至无可见异物后用消毒剂浸泡半小时进行消毒。
夜钓技巧You should u a parate cloth to clean the floor drain. Rag cleaning and disinfecting should be in accordance with the “SOP for cleaning of mops and rags 1-00020”, and the brush should be rind with the process water to no visible stains and disinfected with a disinfectant soak for half an hour after each u.
3.清洁、消毒频次
Cleaning, disinfection frequency
3.1.地漏清洗频次视地漏所在场所环境而定。
The floor drain cleaning frequency is decided to the environment.
—一般区正常使用的地漏每天清洗、液封一次；非正常使用的地漏每周清洗、液封一次；一般区地漏每周至少用75%乙醇或公司规定的其他消毒剂消毒一次；受到污染的地漏需及时清洗、消毒、液封。
In the general area, normally ud floor drain should be cleaned and liquid aled once a day; abnormally ud floor drain should be cleaned and liquid aled once a week; floor drain in the general area should be disinfected once a week at least with the 75% ethanol or other prescribed disinfectant; and it should be cleaned, disinfected, and liquid aled immediately if it is polluted.
—
洁净区正常使用的地漏每天清洗、消毒、液封一次；非正常使用的地漏每3天清洗、消毒、液封一次；受到污染的地漏需及时清洗、消毒、液封。
In the clean area, normally ud floor drain should be cleaned, disinfected, and liquid sealed once a day; abnormally ud floor drain should be cleaned, disinfected, and liquid sealed every three days. It should be cleaned, disinfected and liquid aled immediately if it is polluted.
3.2.清洁剂和消毒剂的使用要求参见《清洁剂和消毒剂使用规程1-00016》。
The u requirement of detergent and disinfectant e the “SOP for Using Detergent and Disinfectant 1-00016”.
六．制定依据 Basis
本文件制定依据为《药品生产质量管理规范（2010年修订）》。
This document is established according to <Good Manufacturing Practice(2010 revision)>
(GMP2010).
七．相关文件和记录Related Documents and Records
1.相关文件Related Documents
文件编号Code | 文件名称Title |
1-00016 | 清洁剂和消毒剂使用规程 SOP for Using Detergent and Disinfectant |
日本好玩吗1-00020 | 国家扶贫项目拖把和抹布的清洁规程 SOP for cleaning of mops and rags |
| |
形容草地的词语
2.相关记录Related Records
